Rough-country 7599 Bedienungsanleitung PDF herunterladen

92759900

99-06 2WD GM 1500 COIL SPACER

Thank you for choosing Rough Country for all of your suspension needs.

Rough Country recommends a certified technician installs this system. In addition to these instructions, professional

knowledge of disassemble/reassembly procedures as well as post installation checks must be known. Attempts to install

this system without this knowledge and expertise may jeopardize the integrity and/or operating safety of the vehicle.

Please read all the instructions before beginning the installation. Check the kit hardware against the Kit Contents list on

next page. Be sure you have all the needed parts and understand where they go. Also please review the tools needed

list to be certain that you have the tools necessary to complete the installation.

PRODUCT USE INFORMATION

As a general rule, the taller a vehicle is the easier it will roll. We strongly recommend that seat belts and shoulder har-

nesses should be worn at all times. Braking performance and capabilities are decreased when significantly larger/

heavier tires and wheels are used. Do no add, alter, or fabricate any factory or after-market parts which increase vehicle

height over the intended height of the Rough Country product purchased. Rough Country makes no claims regarding

lifting devices and excludes any and all implied claims. We will not be responsible for any product that is altered.

Due to differences in manufacturing, dimension and inflated measurements, tire and wheel combinations should be test

fit prior to installation. This kit was developed using a 265/75-16 on stock wheel.

NOTICE TO DEALER AND VEHICLE OWNER

Any vehicle equipped with any Rough country product must have the “Warning to Driver” decal installed on the sun visor

or dash. The decal is to act as a constant reminder for whoever is operating the vehicle of its unique handling character-

istics. INSTALLING DEALER—It is your responsibility to install the warning decal and to forward these installation in-

structions on too the vehicle owner for review and to be kept in the vehicle for its service life.

INSTALLATION INSTRUCTIONS

Tools Needed:

Floor Jack

Jack Stands

Hammer

Pry Bar

WD40

18mm Socket / wrench

15mm Socket / Wrench

12mm Socket / Wrench

10mm Socket / Wrench

PHOTO 1 PHOTO 2

1. Set the emergency brake and chock rear tires to prevent rolling.

2. Jack up the front of the vehicle with a floor jack. Place jack stands on the frame rail directly behind the lower control

arm mounts. Lower the vehicle onto the jack stands. Remove tires and wheels.

3. Remove the bolt that secures the brake line to the knuckle using a 10mm wrench. See Photo 1.

4. Remove the ABS wire from the mounts on the control arm and from the clip on the upper coil seat. See Photo 2.

1 2 3 4

Inhaltsverzeichnis

Seite 1

92759900 99-06 2WD GM 1500 COIL SPACER Thank you for choosing Rough Country for all of your suspension needs. Rough Country recommends a certifie

Seite 2

5. Remove the brake caliper using a 18mm socket and secure out of the way. See Photo 3. Remove the brake rotor and set aside.

Seite 3

11. Remove the sway bar using a 15mm wrench. See Photo 9. 12. Strike to dislodge the lower ball joint as shown in Photo 10 and remove the lower nut

Seite 4

POST INSTALLATION INSTRUCTIONS 1. Check all fasteners for proper torque. Check to ensure for adequate clearance between all rotating, mobile, fixed-

Kommentare zu diesen Handbüchern

Keine Kommentare

Rough-country 7599 Bedienungsanleitung

Stöbern Sie online oder laden Sie Bedienungsanleitung nach Für das Auto Rough-country 7599 herunter. Rough Country 7599 User Manual Benutzerhandbuch

Inhaltsverzeichnis

Kommentare zu diesen Handbüchern

Verwandte Produkte und Handbücher für Für das Auto Rough-country 7599